Printer Friendly

Histological changes of tissues and cell wall of rice straw influenced by chemical pretreatments.

ABSTRACT: Sodium hydroxide (SH) or ammonium bicarbonate (AB) were applied to rice straw to investigate the effects on histological change of stem tissue or cell wall before and after in sacco degradation using a scanning electron microscope (SEM) and a transmission electron microscope (TEM). The SEM revealed that, the parenchyma and vascular bundles were distorted by treatment with SH at 30 or 45 g/kg straw dry matter. Faultage between phloem of large vascular bundles and parenchyma occurred with further increasing SH to 60 or 75 g/kg. The cell wall in these stem tissues was crimped when observed by TEM. However, only parenchyma and large vascular tissues were slightly distorted in AB-treated stem. For untreated and AB-treated stems, the initiation of observable ruminal degradation of cell wall was prolonged from 12 h for inner parenchyma to 24 h for sclerenchyma and to 48 h for phloem of small vascular bundles, while the outer epidermis was intact even at 72 h. For SH-treated stem, however, the cell wall from all of the investigated tissues, epidermis, small vascular bundles, sclerenchyma, and parenchyma started to be degraded at 12 h incubation. These results indicate that SH treatment contracts rice straw stem leading to an improvement in rumen degradation, and that the degradation of SH-treated stem is bilateral from inner and outer surface simultaneously. (Key Words : Chemical Treatment, Electron Microscope, Histological Changes, Rice Straw Stem, Rumen Degradability)

INTRODUCTION

Rice straw (RS) is an important forage for ruminants in many rice-producing countries. Making full use of RS for animal production can save grain, provide additional income to farmers and decrease environment pollution due to burning of straw after harvest (Promkot et al., 2007; Wora-anu et al., 2007). Development and application of chemical treatments for upgrading straw has stimulated intense interest in the developing countries since the 1970's, but there are still some blind spots on the mechanism with which the treatments improve the nutritive value of straw.

Different types of cells of straw are distinct in their digestibility (Akin and Burdick, 1981; Engels and Schuurmans, 1992; Migne et al., 1996), and respond to chemical treatments in a different way (Shen et al., 1999). Structural methods offer effective ways to evaluate digestion of specific cell types and have increased understanding of the contribution of plant and rumen microbial factors in digestion of forages (Akin, 1989; Liu et al., 2005). However, the subjectivity of the sampling and observing has made some acquired results unbelievable or warped. Straw has distinct structure and chemical composition from the upper internode to base internode during growth, and hence differs in degradability between internodes (Migne et al., 1996). Therefore, sampling site is an important factor for acquiring comparable results. Initial microbial colonization occurs at sites of tissue damage (Bauchop, 1980). Use of a small particle of sample is prone to result in selective degradation by the micro-organisms and impaired observability of treatment effects. On the other hand, the holistic domino effect of treatments could be observed if samples were observed at a long interval.

With electron microscopes based on strict sampling and observing rules, Wang et al. (2007) found that sodium hydroxide and ammonium bicarbonate exerted their influence on epidermal histology of RS stem with different modes, resulting in different degradability of RS stem epidermis. However, these changes of epidermis were not related to straw degradability. Microbial digestion that occurred and progressed from more digestible inner tissue had been observed under microscope (Migne et al., 1996). Histological investigation of both inner and outer tissues of straw stem may reveal selective degradation by rumen microorganisms.

[FIGURE 1 OMITTED]

The objective of the present study was to reveal the mechanism for improved degradability of chemically pretreated straw. Scanning electron microscope (SEM) and transmission electron microscope (TEM) were applied to investigate the histological changes of stem tissue or cell wall related to different chemical treatments before and after in sacco degradation.

MATERIALS AND METHODS

Plant materials

The RS used was from late season rice (variety V. Yiu64), cultivated in Zhejiang province of China. The RS used in this experiment was the same as that in Wang et al. (2007).

Chemical pretreatments and stem samples

Effects of treatments with sodium hydroxide (SH) and ammonium bicarbonate (AB) were investigated in this study. Dosages of SH were 15, 30, 45, 60 and 75 g/kg straw DM and dosages of AB were 30, 60, 90, 120 and 150 g/kg DM. For practical considerations and evaluation of pretreatment efficacy, 500 g of chopped RS (3-5 cm, air-dried) and 15 sub-stem samples were treated together in three replicates of each treatment level. The amount of water used to dissolve the SH or AB was controlled to adjust the initial moisture content of the treated RS to about 400 or 500 g/kg, respectively. After the RS and sub-samples of stem were thoroughly mixed with the SH or AB solution, the sealed bags with straw were placed in a container at 35[degrees]C for 3 or 10 days, respectively. Untreated RS and stem were used as control treatments.

The 15 sub-stem samples in every pretreatment were selected as follows: each 3 cm stem sample was taken from 2 cm below the second rice stem node, and then it was longitudinally cut into six parts, which were distributed randomly to the five different dosages in SH or AB as well as the control (Figure 1). To ensure that three stem subsamples from every pretreatment were used for each incubation time in the rumen of a sheep, 15 sub-stem samples were prepared from 15 random samples.

Chemical pretreatment efficacies were evaluated in terms of the changes of crude protein, ash, neutral detergent fiber (NDFom), and in sacco dry matter degradability (DMD) of RS. The details of chemical analysis and measurement of DMD were as described elsewhere (Wang et al., 2007).

Stem sub-samples for microscopic investigation before degradation

Before they were prepared for microscopic investigation, the untreated and treated sub-stems were immersed in cold water for 12 h to keep their structure intact. The procedures for preparation of samples for SEM and TEM were as described by Liu et al. (2005), except for embedding during preparation of samples for TEM where dehydrated samples were embedded in resin according to the following procedure: acetone/resin (1:1, v/v) for 1 h, acetone/resin (1:3, v/v) for 3 h, pure resin overnight and then samples were transferred to tubes filled with resin and polymerized at 70[degrees]C for at least 12 h.

Stem sub-samples for microscopic investigation after degradation

Based on results from SEM and for practical considerations, the sub-samples of stem treated with SH at 45 g/kg DM and with AB at 90 g/kg DM were used for in sacco incubation. Separated from DMD determination, only one tagged sub-stem was put into a nylon bag (40 [micro]m mesh, 2 cmx5 cm inner size) to prevent sub-stems from adhering to each other. All untreated and treated sub-stems were suspended in the rumen of three rumen-fistulated Huzhou sheep for 12, 24, 48 and 72 h (Orskov et al., 1980). For every pretreatment, 3 incubated sub-stems could be acquired at each time from every sheep. At the end of degradation, bags were immediately immersed in running cold water, gently washed by hand for 20 min and then the samples were immediately prepared for electron microscope observation. The cut ends of all incubated sub-stems had 1 mm cut off to eliminate the cutting effect before materials were prepared for microscopic investigation.

Statistical analysis

Data for chemical composition and DMD of straw were analyzed by the general linear models procedure of SAS (1999). Linear and quadratic effects of increasing dosage of treatment were determined using orthogonal polynomial contrasts (Steel and Torrie, 1980).

RESULTS AND DISCUSSION

Chemical composition and in sacco degradability of rice straw

The results for chemical composition and the increased in sacco DMD (Table 1) in pretreated RS are comparable to other results (Liu et al., 2002; Suksombat, 2004) which indicated that both treatments in this experiment were effective, i.e. the pretreated-stems could be used for histological investigation.

[FIGURE 2 OMITTED]

Histological changes of tissues and cell wall of rice straw influenced by pretreatment

The changes of tissues : Histological changes of tissues of untreated, SH and AB-treated RSs are shown in Figure 2. The cells were clearly observable in or around the vascular bundles in untreated-stem (Figure 2, SH0, arrow). When SH increased to 30 or 45 g/kg DM, the parenchyma and the vascular bundles were so distorted that the figure of cells was irregular in the connection between the rind and pith regions, and the cells could not be clearly observed in or around the vascular bundles (Figure 2, SH30 and SH45, arrow). Faults could be observed between phloem of large vascular bundles and the parenchyma under SEM with increasing dosage of SH to 60 (Figure 2, SH60) or 75 g/ kg DM (picture not shown). Contrary to SH treatment, only slight distortion of parenchyma and large vascular bundles could be observed in AB-treated stems (Figure 2, AB30 to AB120).

The changes of cell wall : The TEM of cell wall from sclerenchyma, parenchyma and vascular bundles of different straws are presented in Figure 3. All the cell walls were crimped with SH treatment, while these changes could not be observed in AB-treated cell walls (Figure 3, arrow).

The histological changes after treatment indicate the modification of stem structure. The distorted figure of SHtreated parenchyma was reflective of the contraction of stem, while the crimp in SH-treated vascular bundles might be the swelling character of the contracted stem after immersion in water during preparation of stem samples. The contracted stem of SH-treated straw may be caused by high permeation of sodium ions (Bergen, 1972; Meryman, 1973). It has been speculated that cellulose within the cell wall matrix may be physically restrained from swelling and alkali treatments may reduce the strength of inter-molecular hydrogen bonds that bind cellulose molecules together and remove these restraints to a certain extent (Han and Garrett, 1986). The contraction and swelling was consistent with the results of volumetric weight and swelling capacity changes (Wang et al., 2006). Liquid ammonia has the ability to form an ammonia-cellulose complex and to decrease the crystallinity of cellulose (Isogai and Usuda, 1992). Goto and Yokoe (1996) observed that gaseous ammonia-treated barley straw had 14% lower ratio of crystalline to amorphous regions than did untreated straw. In this study, lack of effect of AB on histological changes suggests the weakness of AB on cell wall matrix.

[FIGURE 3 OMITTED]

Histological changes of tissues and cell wall of pretreated rice straw after rumen incubation

The degradability of all the sub-stem samples observed in three animals was similar for every pretreatment. Therefore, only the results from one sub-stem sample obtained in the same animal are shown for every pretreatment. The SEM and TEM pictures for every pretreatment at each incubation time were from a single sub-stem sample.

The changes of tissues : Histological changes of tissues after rumen incubation are shown in Figure 4. Parenchyma of RS was more degradable than sclerenchyma, and the large vascular bundles were separated from the parenchyma before their degradation could be observed in untreated stem (Figure 4, SH0). After in sacco degradation for 12 h, the SH-treated stem was so fragile that it cracked during preparation for microscopic investigation. Sporangia were also observed on the exo--or endo-stem surface (Figure 4 SH45, arrows and ring). At 24 h of incubation, both parenchyma and large vascular bundles were colonized by sporangia of rumen fungi (arrow in Figure 4, SH45) and slight degradation of small vascular bundles could be observed under SEM (ring in Figure 4, SH45). At 48 h of incubation, only a thin layer of sclerenchyma was observed (Figure 4, SH45), and the sclerenchyma layer became so thin that it was impossible to keep its integrity for microscopic observation at 72 h incubation. The degradation of SH-treated stem was consistent with the increase of DMD detected with whole straw in this study. However, with the limitation of microscopy, the AB-treated stem (Figure 4, AB90) could not be observed to be more degradable than the untreated one under SEM (Figure 4 SH0), in spite of a slight increase in DMD of AB-treated RS (395 vs. 327 g/kg, Table 1).

The changes of cell wall : Cell wall from epidermis, small vascular bundles, sclerenchyma, and parenchyma observed under TEM are shown in Figure 5. Degradation of AB-treated stem cell wall (AB90) was similar to that of the untreated (SH0). None of the cell wall layers of untreated and AB-treated epidermis was digestible, even if they were incubated in the rumen for 72 h. However, cell wall degradation in the small vascular bundles could be observed at 48 h incubation. The sclerenchyma cells connected to parenchyma tissues (between the rind and pith) were degraded earlier than those of small vascular bundles at 24 h rumen incubation, while degradation of parenchyma cells could be clearly observed at 12 h incubation. These changes indicated that the degradation of untreated and AB-treated stems was from inner to outer side. Contrary to untreated and AB-treated stems, in SH-treated stem the degradation of cell wall could be clearly observed in all the investigated Dtissues, i.e., epidermis, small vascular bundles, sclerenchyma and parenchyma at 12 h incubation (Figure 5, SH45), suggesting that the SH-treated stems are degraded bilaterally, from inner and outer surface simultaneously.

[FIGURE 4 OMITTED]

Akin et al. (1974) found that rumen bacteria preferentially degrade the region below the cuticle of epidermal cells. Eventually, bacteria degrade all the epidermal cell wall except the protective cuticle. The bacteria do not attach to the cuticle, which is dissociated from the epidermis during degradation. In order to eliminate the selective degradation effect by rumen microorganisms, the cut end of the stem was removed before the preparation of samples for microscopy in the present study. With this cutting operation, it was observed that none of the cell wall layers of untreated and AB-treated epidermis was digestible, even if they were incubated in the rumen for 72 h (Figure 5, SH0 and AB90), whereas the degradation of epidermis in SH-treated stem could be clearly observed at 12 h incubation (Figure 5, SH45).

Histological pictures revealed the different degradation between SH and AB-treated straw, and the important roles of microorganisms in the rumen degradation. However, it is difficult to quantify microbial population from either SEM or TEM pictures directly. Using real-time PCR, Lee et al. (2007) revealed the change of cellulolytic bacterial adhered to the treated straw quantitatively. Fluorescence in situ hybridization (FISH), as a technique allowing simultaneous visualization, identification, enumeration and localization of individual microbial cells, is being widely used in many fields of microbiology (Moter and Gobel, 2000). Further work is needed to use these techniques to quantitatively explore the interaction of rumen microorganisms.

[FIGURE 5 OMITTED]

CONCLUSIONS

Treatment with sodium hydroxide resulted in contracted parenchyma, sclerenchyma and vascular bundles of rice straw, had a strong effect on stem structure and hence improved degradation may be expected from the treated straw. Effect of treatment with ammonium bicarbonate on stem structure was inferior to that of sodium hydroxide. The degradation of the stems treated with sodium hydroxide and ammonium bicarbonate showed different modes: the sodium hydroxide-treated straw was degraded bilaterally from inner and outer surface simultaneously, while the stem treated with ammonium bicarbonate was degraded only from the inner side.

ACKNOWLEDGMENTS

This research was supported by a grant from the National Natural Science Foundation of China (No.30270943). Authors thank Ms. Junying Li and Mr. Liping He of the Center of Analysis and Measurement of Zhejiang University for assistance in use of electron microscopes.

Received August 27, 2007; Accepted January 4, 2008

REFERENCES

Akin, D. E. 1989. Histological and physiological factors affection digestibility of forages. Agron. J. 81:17-25.

Akin, D. E. and D. Burdick. 1981. Relationships of different histochemical types of lignified cell wall to forage digestibility. Crop Sci. 21:577-581.

Akin, D. E., D. Burdick and G. E. Michaels. 1974. Rumen bacterial interrelationships with plant tissue during degradation revealed by transmission electron microscopy. Appl. Microbiol. 27:1149-1156.

Bauchop, T. 1980. Scanning electron microscopy in the study of microbial digestion of plant fragments in the gut. In: Contemporary microbial ecology (Ed. D. C. Ellwood, J. N. Hedger, M. J. Latham). Academic Press, London, pp. 305-326.

Bergen, W. G. 1972. Rumen osmolality as a factor in feed intake control of sheep. J. Anim. Sci. 34:1054-1060.

Engels, F. M. and J. L. L. Schuurmans. 1992. Relationship between structural development of cell walls and degradation of tissues in maize stems. J. Sci. Food Agric. 59:45-51.

Goto, M. and Y. Yokoe. 1996. Ammoniation of barley straw. Effect on cellulose crystallinity and water-holding capacity. Anim. Feed Sci. Technol. 58:239-247.

Han, I. K. and W. N. Garrett. 1986. Improving the dry matter digestibility and voluntary intake of low quality roughages by various treatments: a review. Kor. J. Anim. Sci. 28:199-236.

Isogai, A. and M. Usuda. 1992. X-ray diffraction and solid-state 13C-NMR analyses of celluloses treated with ammonia. Mokuzai. Gakkaishi. 38:562-569.

Lee, C. H., H. G. Sung, M. Eslami, S. Y. Lee, J. Y. Song, S. S. Lee and J. K. Ha. 2007. Effects of tween 80 pretreatment on dry matter disappearance of rice straw and cellulolytic bacterial adhesion. Asian-Aust. J. Anim. Sci. 20:1397-1401.

Liu, J. X., A. Susenbeth and K. H. Sudekum. 2002. In vitro gas production measurements to evaluate interactions between untreated and chemically treated rice straws, grass hay, and mulberry leaves. J. Anim. Sci. 80:517-524.

Liu, D., J. X. Liu, S. L. Zhu, X. J. Chen and Y. M. Wu. 2005. Histological investigation of tissues and cell wall of rice straw influenced by pretreatment with different chemicals and rumen degradation. J. Anim. Feed Sci. 14:373-387.

Meryman, H. T. 1973. Influence of certain neutral solutes on red cell membrane area and permeability during hypotonic stress. Am. J. Physiol. 225:365-371.

Migne, C., E. Grenet and J. Jamot. 1996. Microbial degradation of the apical internode of Co125 and W401 maize in the rumen. Anim. Feed Sci. Technol. 58:165-185.

Moter, A. and U. B. Gobel. 2000. Fluorescence in situ hybridization (FISH) for direct visualization of microorganisms. J. Microbiol. Methods 41:85-112.

Orskov, E. R., F. D. Hovell and F. Mould. 1980. The use of the nylon bag technique for the evaluation of feedstuffs. Trop. Anim. Prod. 5:195-213.

Promkot, C., M. Wanapat and P. Rowlinson. 2007. Estimation of ruminal degradation and intestinal digestion of tropical protein resources using the nylon bag technique and the three-step in vitro procedure in dairy cattle on rice straw diets. Asian-Aust. J. Anim. Sci. 20:1849-1857.

SAS User's Guide, 1999: Statistics, version 8. SAS Inst, Inc, Cary, NC.

Shen, H. Sh., F. Sundstol, E. R. Eng and L. O. Eik. 1999. Studies on untreated and urea-treated rice straw from three cultivation seasons: 3. Histological investigations by light and scanning electron microscopy. Anim. Feed Sci.Technol. 80:151-159.

Steel, R. D. G. and J. H. Torrie. 1980. Principles and Procedures of Statistics, McGraw-Hill, New York, USA.

Suksombat, W. 2004. Comparison of different alkali treatment of bagasse and rice straw. Asian-Aust. J. Anim. Sci. 17:14301433.

Wang, J. K., J. X. Liu, Y. M. Wu and J. A. Ye. 2006. Improvement of organic matter digestibility with changes in physical properties of rice straw by chemical treatments. J. Anim. Feed Sci. 15:147-157.

Wang, J. K., J. X. Liu, J. Y. Li, Y. M. Wu and J. A. Ye. 2007. Histological and rumen degradation changes of rice straw stem epidermis as influenced by chemical pretreatment. Anim. Feed Sci. Technol. 136:51-62.

Wora-anu, S., M. Wanapat, C. Wachirapakorn and N. Nontaso. 2007. Effect of roughage sources on cellulolytic bacteria and rumen ecology of beef cattle. Asian-Aust. J. Anim. Sci. 20:1705-1712.

Jia-Kun Wang, Xiao-Lian Chen, Jian-Xin Liu *, Yue-Ming Wu and Jun-An Ye

College of Animal Sciences, MOE Key Laboratory of Molecular Animal Nutrition Zhejiang University, Hangzhou 310029, China

* Corresponding Author: Jian-Xin Liu. Tel: +86-571-86971097, Fax: +86-571-86971930, E-mail: liujx@zju.edu.cn
Table 1. Effects of treatment with sodium hydroxide (SH) and
ammonium bicarbonate (AB) on chemical composition (g/kg DM) and in
sacco degradability (g/kg) of rice straw

 Rice straw treated by

Indices None SH (g/kg DM)

 0 15 30 45 60 75 RMSE (a)

NDFom (cd) 727 695 680 644 609 576 17.2
CP (d) 55 66 57 61 57 56 2.8
Ash (d) 123 147 151 160 181 180 11.2
DMD (e) 327 448 546 620 649 739 28.0

 Rice straw treated by Effect (b)

Indices AB (g/kg DM) SH AB

 30 60 90 120 150 RMSE L Q L Q

NDFom (cd) 737 725 709 709 701 12.2 ** NS ** NS
CP (d) 60 71 90 93 101 4.1 NS * ** NS
Ash (d) 121 126 120 124 125 6.4 ** NS NS NS
DMD (e) 338 383 395 421 441 23.1 ** * ** NS

(a) RMSE = Root mean squares error. (b) L = Linear; Q = Quadratic;
* p<0.05; ** p<0.01; NS = p>0.05. (c) NDFom = Neutral detergent fiber
not assayed with a heat stable amylase and expressed exclusive of
residual ash. (d) From Wang et al. (2007). (e) DMD = In sacco DM
degradability at 48 h of incubation.
COPYRIGHT 2008 Asian - Australasian Association of Animal Production Societies
No portion of this article can be reproduced without the express written permission from the copyright holder.
Copyright 2008 Gale, Cengage Learning. All rights reserved.

Article Details
Printer friendly Cite/link Email Feedback
Author:Jia-Kun, Wang; Xiao-Lian, Chen; Jian-Xin, Liu; Yue-Ming, Wu; Jun-An, Ye
Publication:Asian - Australasian Journal of Animal Sciences
Article Type:Report
Geographic Code:9CHIN
Date:Jun 1, 2008
Words:3558
Previous Article:In vitro methanogenesis, microbial profile and fermentation of green forages with buffalo rumen liquor as influenced by 2-bromoethanesulphonic acid.
Next Article:Effect of methionine supplementation on performance and carcass characteristics of awassi ram lambs fed finishing diets.
Topics:


Related Articles
Fungi prefer UV-treated diet.
Tox/Path team takes on differential gene expression.
Combine enzymatic pectin modification and high-pressure shift freezing to minimize texture loss.

Terms of use | Privacy policy | Copyright © 2019 Farlex, Inc. | Feedback | For webmasters