Printer Friendly

High-tech, water heaters: new technology can save energy and money.

Water heater technology is changing--fast! And even though all the new models are more energy efficient, that doesn't mean you'll find them the most cost effective for your family. So before you plunk down big bucks for a high-tech heater, take a minute to understand how each style works, its pros and cons, and its projected payback. Your goal is to find the Tight balance between performance and efficiency for your particular home. However, if you're really into numbers crunching, use the worksheets at energysavers.gov.

First, check the ratings

There are two ratings to check before you buy any heater: the energy factor (EF), which tells you how efficient it is, and the first-hour recovery (for storage tank heaters) or flow rate (for tankless).

The EF is easy to understand--the higher the number, the more efficient the unit. Interpreting the recovery rate is similar--the higher the number, the more hot water you'll get in the first hour after opening the spigot. But when it comes to ratings for tankless water heaters, keep in mind that lower groundwater temperatures can sometimes cut the heater's flow rate by half. So shop for one that'll provide the flow rate you want, on the basis of incoming winter water temperatures.

[ILLUSTRATION OMITTED]

Tankless

Instead of keeping 40 or 50 gallons of hot water on call 24 hours a day--which wastes energy--a tankless unit heats water only when you need it. A flow sensor detects when you open the faucet. Then the gas valve opens and the burners fire up. The heater measures the incoming water temperature and calculates how quickly the water should flow past the burners. So, if the incoming water is 65 degrees F (typical summer temperature), the heater will provide its maximum flow rate. But if the water is only 35 degrees, the heater will throttle back the flow rate by almost 50 percent. Check with your local utility to find out the water temperature. The average home center price for a tankless heater is $1,000, plus about $200 for a stainless vent.

[ILLUSTRATION OMITTED]

Pros:

* Nothing beats a tankless heater for putting out lots of hot water--it never runs out.

* A tankless heater saves about 30 to 50 percent in energy costs over a conventional gas heater (minimum EF of .82 vs. .54 for conventional).

* A tankless heater is small and hangs on the wall, freeing up floor space.

Cons:

* With tankless heaters, there's a lag time of three to eight seconds to fire up the burners and heat the water to the set temperature.

* Installation can be a major project.

* Tankless heaters must be flushed annually with special chemicals to remove scale and maintain energy efficiency. You can do this yourself or hire a plumber (about $125).

What to look for:

Shop for one with the highest EF and the best flow rate.

Is it DIY?

You can install it yourself--if you can run a new gas line, follow the venting installation instructions to the letter (and to your local code), install an electrical outlet, and reconfigure the water pipes. It's a big job.

Is it for you?

If you want an endless supply of hot water for long showers or to fill a gazillion-gallon spa, this heater's for you. Just be aware that you may not be able to run several showers at the same time in winter.

The payback on a professionally installed tankless heater is 16 to 22 years, or six years if you install it yourself.

For more information

* boschhotwater.com

* eternalwaterheater.com/products.html

* hotwater.com/lit/spec/r-gas.html#tankless

* navienamerica.com

* rheem.com/products/tankless_water_heaters

* rinnai.us

* statewaterheaters.com

Electric hybrid heat pump

Hybrid heat-pump water heaters work by pulling heat out of the surrounding air and pumping it into the storage tank. So if you live in a warm climate and install it in your hot attic or garage, the heat pump alone can save you money. The conventional heating coils come on only when the heat pump can no longer satisfy the demand.

[ILLUSTRATION OMITTED]

If you install the water heater in a heated room, it will suck some of the heat. However, if you heat the house with gas, you'll probably still come out ahead.

Hybrid heat pump water heaters cost about $1,500 at home centers.

Pros:

An electric hybrid heat pump has the lowest operating cost of any electric water heater on the market, especially when installed in warm climates.

Cons:

* Hybrids cost about $1,000 more than a conventional electric heater.

* The heat pump is taller (and wider in some cases) than your existing electric heater. Make sure the unit will fit.

* Some heaters are "side-piped" to eliminate the possibility of heat pump damage caused by leaking pipes. On those models, you'll have to reconfigure the water pipes.

* You'll have to clean the air filter regularly to maintain operating efficiency.

* The heater needs at least 1,000 cu. ft. of air surrounding it, so it can't be installed in a closet.

What to look for:

EF rating of 2.0 and the highest "first-hour rating."

Is it DIY?

If you can reconfigure the water pipes and connect the wiring, you can install this yourself. But heed this warning: These suckers are big and heavy (about 200 lbs. empty). Get some help!

Is it for you?

If you live in a warmer climate and heat water with electricity, an electric hybrid heat pump will save you the most money over a conventional heater. In colder climates, it'll still save money during the summer when you're not paying to heat the surrounding air. The higher your electric rates and the warmer the year-round climate, the faster the payback. In many cases, the payback can be as little as four years.

For more information

* americanwaterheaternews.com/new_products/hybrid_elec.htm

* geappliances.com/heat-pump-hot-water-heater/

* hotwater.com/products/residential/voltex_hybrid.html

* rheem.com/products/tank_water_heaters/hybrid_electric

Condensing gas heaters

Like conventional heaters, condensing gas heaters have a tank. But that's where the similarity ends. Instead of sending hot exhaust gases out the flue, which wastes energy, this heater blows them through a coil at the bottom of the tank. Incoming cold water flows around the coil and collects most of the heat. That's why condensing gas water heaters are so efficient (up to 96 percent thermal efficiency).

Even though it's a storage tank design with "standby loss," the increased efficiency more than offsets that loss.

[ILLUSTRATION OMITTED]

Condensing gas water heaters cost about $2,000 (from online sources like pexsupply.com--home centers don't sell this style right now). But by mid-2011, manufacturers will begin introducing lower-priced models (about $1,200) at home centers.

Pros:

* A condensing gas heater is the most energy-efficient, gas-fired tank-style water heater on the market.

* "First-hour" recovery rate is incredible--you'll never run out of hot water.

Cons:

* A condensing heater costs $2,000. New models coming out in 2011 will still cost two to three times more than conventional.

* It requires gas line and venting reconfiguration.

* There's no "real-world" experience on tank life or repair costs.

What to took for:

Shop for a heater with a thermal efficiency of at least 90 percent.

Is it DIY?

If you know how to reconfigure gas pipe, install new venting and add a 110-volt receptacle, you can install this heater.

is it for you?

If you're replacing an existing gas water heater and need lots of hot water for long or multiple showers and tub fills, and want a high flow rate in summer and winter, this may be the way to go. It requires the least amount of repiping and has a faster payback. Figure a 12-year payback at current prices, or an eight-year payback when the lower-priced models arrive in fall 2011.

For more information

* hotwater.com/products/residential/rg-vertex100.html

Electric point-of-use tankless

A "POU" heater can't replace your main water heater. But it can cut your water bill by eliminating the waste that occurs while you're waiting for hot water to arrive at the tap. The heater (which is about the size of a cigar box) installs under the sink and connects between the cold water valve and the hot water faucet.

[ILLUSTRATION OMITTED]

POU heaters cost about $230 at home centers and online.

Pros:

* A point-of-use heater reduces water waste and dramatically shortens the wait for hot water.

* It boosts the efficiency of your main water heater, eliminating frequent cycling from faucets.

Cons:

* A point-of-use heater adds cost to your water heater project.

* It requires a new 220-volt or 110-volt high-amperage circuit.

What to look for

The highest EF and best flow rate based on winter water temperatures.

Is it DIY?

If you know how to run a 110-volt or 220-volt circuit, you can install this water heater. The plumbing is a no-brainer.

Is it for you?

If you have long runs from the water heater to kitchen and bath faucets, a POU heater is the best solution. A point-of-use heater offers about a three-year payback based on water savings alone.

For more information

* boschhotwater.com

* hotwater.com/products/residential/rg-ondemand.html

* rheem.com/products/tanktess_water_heaters/tankless_electric

* stiebel-eltron-usa.com/mini.html

Conventional gas

Conventional water heaters have improved in recent years. They now have thicker insulation, motorized-dampers to reduce heat loss, and an EF of at least .67.

[ILLUSTRATION OMITTED]

Pros:

* Lowest upfront cost.

* Easiest to install.

* No fans or pumps to burn out. Proven reliable over decades of use.

Cons:

* Less efficient; more expensive to run.

Is it for you?

If you need an immediate replacement, you don't plan to stay in your home for years or you just don't use a lot of hot water, a conventional unit may be your most cost-effective option.

famityhandyman.com

* Learn how to install a power-vented water heater. Search for "power vent."

* Want to learn how to work with copper pipes? Search for "copper pipe."

* Find out how to run a new receptacle for your water heater. Search for "electric outlet."

by Rick Muscoplat

editors@thefamilyhandyman.com
COPYRIGHT 2010 Home Service Publications, Inc.
No portion of this article can be reproduced without the express written permission from the copyright holder.
Copyright 2010 Gale, Cengage Learning. All rights reserved.

Article Details
Printer friendly Cite/link Email Feedback
Author:Muscoplat, Rick
Publication:The Family Handyman
Geographic Code:1USA
Date:Dec 1, 2010
Words:1682
Previous Article:How to choose a toilet dunny, bog, water closet, loo, potty, head, john crapper, porcelain god, commode, throne, W.C., can that you'll love.
Next Article:Stainless steel kitchen backsplash.
Topics:

Terms of use | Privacy policy | Copyright © 2021 Farlex, Inc. | Feedback | For webmasters |